Sweep & inspection
Caps & crowns
Flue relining
Masonry repair
Gas fireplace serviceLevel 1 sweep and inspection to the NFPA 211 annual standard - flue, crown, cap, and flashing checked and photographed
Chimney sweep logs do not sweep chimneys. They loosen some creosote - which then falls where a brush and vacuum still have to collect it.
Chimney Company in Tustin, CA
Chimney repair in Tustin spans two very different housing stocks: the 1950s ranch homes around Old Town with original brick masonry and clay tile flues, and the 1990s – 2000s stucco homes in Tustin Ranch with factory-built gas fireplaces and direct-vent systems. Each requires different repair parts, different liner materials, and a technician who can tell which one your home actually has. Oakleaf Chimney Sweep handles both, and we’ve served Tustin since 2016. Call (855) 362-1450 when something’s not drafting right or you smell smoke inside the living room.
Why Tustin Homes Are Different
Tustin pairs two fireplace generations under one city line, and that split changes everything about how a chimney should be repaired. In the 92780 ZIP around Old Town, mid-century ranch houses were built with full masonry fireplaces, clay tile flue liners, and metal damper assemblies that are now sixty to seventy years old. The dampers rust through, the mortar crowns crack, and the clay tiles spall after decades of thermal cycling. Over in 92782, Tustin Ranch and Columbus Square homes are mostly direct-vent gas units with B-vent flues, which fail differently: gasket leaks, corroded vent pipe, and improper clearances that original builders sometimes rushed.
The climate adds its own layer. Tustin’s long dry season means creosote hardens and glazes inside flues between the few weeks each winter when fireplaces actually get used. A glaze layer is far harder to remove than fresh creosote, and it’s also more combustible. Then the Santa Ana winds arrive and push hot embers and ash down any uncapped chimney, which is why we recommend annual inspections before the first cool nights, not after a scare. After a significant winter rain, we also recommend a look at the chimney exterior in 92780 specifically: those older mortar crowns leak, and water intrusion is how a $400 repair becomes a $4,000 one.
Styles & brands we work with
Our Main Tustin Services
Most Tustin homeowners call us for one of two things: an annual chimney sweep before burning season, or a dryer vent cleaning when they notice the dryer running long. Both are fire-safety services, and both should be on the same maintenance schedule.
Chimney Sweep in Tustin
A thorough sweep in Tustin means adapting to your house’s era. In an Old Town 92780 ranch, we run traditional rod-and-brush tooling through a clay tile flue that may not have been cleaned in years, and we check the damper assembly at the top of the firebox while we’re there. In a Tustin Ranch 92782 direct-vent gas home, the work shifts to inspecting the B-vent, checking for birds or debris at the termination, and confirming the gas appliance is venting safely. One visit covers either reality. Chimney Sweep in Tustin
Dryer Vent Cleaning in Tustin
Dryer vents clog, overheat, and catch fire just like chimneys, and Tustin’s long dry season makes accumulated lint even easier to ignite. We treat dryer vent cleaning as a core safety service, not an upsell: we pull the dryer, brush the full duct run, clean the exterior termination, and verify airflow at the exterior vent. If the duct run is plastic or crushed, we’ll tell you that too. Dryer Vent Cleaning in Tustin
What happens when you call
- 1
A real person answersNo phone trees — you reach a local pro.
- 2
You get an upfront price rangeHonest numbers before anyone is dispatched.
- 3
A background-checked tech heads outLicensed & insured, dispatched right away.
- 4
You approve before work beginsNothing starts until you say go.
Chimney Repair in Tustin
Chimney repair in Tustin usually means one of two things: restoring an original masonry fireplace in a 1950s – 70s ranch home, or replacing components on a factory-built gas system in Tustin Ranch. In the older 92780 homes, the most common calls we get are for rusted damper assemblies that won’t open or close, cracked mortar crowns that leak during winter rains, and damaged flue liners that are no longer safe to burn with. In 92782, the calls trend toward direct-vent issues: failed gaskets, corroded vent pipe, and missing termination caps. We stock parts from Copperfield and Famco, and use DuraFlex liners and HeatShield restoration compound when a flue liner fails, because those are the materials working chimney professionals specify. If we find damage during a sweep, we can quote and often perform the repair on the spot. Here’s what that looks like on the specific repairs Tustin homes ask for. Read more about our full service hub: Chimney Repair.
Chimney Cap Installation
Signs you need it
You hear birds or animals inside the flue, you see water stains on the firebox walls, or the Santa Anas push ash and embers back down into the house.
What it costs in Tustin
A new chimney cap in Tustin typically runs between $265 and $410 installed, depending on the flue size and whether we need a standard Galvanized cap or a Copperfield copper finish.
How we do it
We measure the flue, select a cap with the right spark-arrestor mesh for your fuel type, and mechanically secure it to the crown or flue tile so wind and birds can’t dislodge it.
Chimney Cap Replacement
Signs you need it
The existing cap is rusted through, the mesh is torn, or the cap has blown off entirely and left the flue open.
What it costs in Tustin
Replacement in Tustin runs from $240 to $370, which includes removing the old rusted unit and disposing of it.
How we do it
We remove the failed cap, inspect the flue for damage underneath, and install a new properly sized cap, sealing the mounting points against water.
Chimney Liner Installation
Signs you need it
Your clay tile flue is cracked or spalled, you smell smoke in adjoining rooms, or your gas appliance is venting into an oversized masonry flue and condensing inside the walls.
What it costs in Tustin
A new DuraFlex stainless steel liner in Tustin typically falls between $2,400 and $3,400 for a single-story ranch, with taller or multi-flue homes running higher.
How we do it
We size the liner to the appliance, feed the DuraFlex system down the existing flue, insulate where the code requires it, and connect it to a properly sized cap and connector at the appliance.
Chimney Flashing Repair
Signs you need it
You see water staining on the ceiling around the chimney chase after rain, or the flashing has pulled away from the roofline and you can see gaps at the shingle line.
What it costs in Tustin
Flashing repair in Tustin runs $350 to $550 for a section repair, while a full re-flash on an old 92780 ranch can run $750 to $950.
How we do it
We cut back the old flashing, replace it with new step and counter flashing, and seal the joint with a high-temperature sealant that holds through Tustin’s hot dry summers and rare heavy rains.
Chimney Crown Repair
Signs you need it
You see cracked or crumbling mortar on the chimney top, or water is entering the flue from above during winter storms, especially in the older 92780 homes.
What it costs in Tustin
A crown repair in Tustin ranges from $275 for resurfacing small cracks to $800 for a full crown rebuild with proper overhang and drip edge.
How we do it
We remove loose mortar, form the crown, and pour a new properly sloped surface with a drip edge so water runs off instead of into the brick below.
What Chimney Repair Costs in Tustin
| Item | Typical range in Tustin |
|---|---|
| Chimney cap installation | $265 – $410 |
| Chimney cap replacement | $240 – $370 |
| Chimney liner installation (DuraFlex) | $2,400 – $3,400 |
| Flashing repair (section) | $350 – $550 |
| Full re-flash | $750 – $950 |
| Crown repair (resurface) | $275 – $400 |
| Crown rebuild (full) | $550 – $800 |
Can you repair a damaged damper on a 1950s Tustin fireplace?
Yes. We replace rusted damper assemblies in old-town Tustin 92780 ranch homes regularly. The job usually takes about an hour once we can access the firebox, and we’ll show you the old part before we install the new one.
How do I know if my Tustin flue liner needs replacing or just resurfacing?
We run a camera inspection and show you the footage. In some Tustin homes, HeatShield restoration can resurface cracked clay tiles for a fraction of a full relining, but only if the damage is limited to surface cracks and the underlying structure is sound.
Brands We Service in Tustin
We stock and install Copperfield caps, Famco dampers and venting, and Olympia Chimney components, and we install DuraFlex liners and HeatShield restoration material. That means we can quote and complete most Tustin repairs the same visit without a second trip to a supplier. Our brands page covers the full list.
See the difference
Before
After
Before
After
Before
AfterPricing for Chimney Company in Tustin, CA
| Service | Typical range in Tustin |
|---|---|
| Chimney sweep (masonry fireplace, 92780) | $179 – $219 |
| Chimney sweep (direct-vent gas, 92782) | $149 – $189 |
| Chimney cap installation | $265 – $410 |
| Chimney cap replacement | $240 – $370 |
| Chimney liner installation (DuraFlex) | $2,400 – $3,400 |
| Chimney flashing repair (section) | $350 – $550 |
| Chimney crown repair (resurface) | $275 – $400 |
| Dryer vent cleaning | $129 – $179 |
| Dryer vent repair (standard) | $90 – $225 |
| Dryer vent replacement (full duct) | $280 – $460 |
What pushes a Tustin chimney repair price up is usually access: a steep roof on a two-story Tustin Ranch home, a flue that requires extra scaffolding, or a liner that has to be ordered in a custom length. We give you an upfront price before any work begins, and that price is the price you pay.
Neighborhoods We Serve in Tustin
We work throughout Tustin, from the 1950s ranches around Old Town to the newer stucco communities in Tustin Ranch and Columbus Square. Our techs carry both masonry and gas-appliance tooling on every truck, so the neighborhood you’re in doesn’t determine whether we can handle the job. Typical arrival for a Tustin call is one to two days after booking.
- Old Town Tustin (92780)
- Tustin Ranch (92782)
- Columbus Square (92782)
- Tustin Meadows (92780)
- Laurelwood (92780)
Service Area – Cities Near Tustin
Oakleaf Chimney Sweep also serves the surrounding Orange County communities. We’re in North Tustin, CA for the hillside homes with steep roof pitches, in Irvine, CA for the newer gas fireplace communities, in Costa Mesa, CA for the older beach-adjacent ranches, and in Aliso Viejo, CA for the planned communities with HOA-maintained exteriors. If you’re unsure whether we cover your street, call (855) 362-1450 and ask.
Serving Tustin, CA — Our Local Coverage Area
We’re based in the Tustin area and know this community well. Use the map below to see our service coverage — if you’re nearby, we can almost certainly help.
FAQs About Chimney Company in Tustin
Most Tustin appointments are scheduled within one to two business days of your call. During the weeks before burning season, we book out further, so calling early in the fall is the best move for an annual sweep.
For interior work like a sweep or liner installation, no. For exterior changes like a chimney cap or crown repair in an HOA community, check your CC&Rs. We can provide a written description of the planned work for your HOA if needed.
Yes. Our trucks carry both traditional rod-and-brush sweeping equipment and gas-appliance testing and venting tools, so we can handle a 1950s brick fireplace in 92780 and a direct-vent gas unit in 92782 on the same day.
Call Oakleaf Chimney Sweep at (855) 362-1450 for a free estimate on any chimney or dryer vent job in Tustin, from an annual sweep to a full liner replacement. We’ll give you a straight answer and an upfront price.
What happens when you call
- 1A real person answersNo phone trees — talk to a local chimney cleaning pro.
- 2You get an upfront price rangeHonest numbers before anyone is dispatched. No surprises.
- 3We come out and measureLicensed & insured, at a time that suits you — the visit and the quote are both free.
- 4You get the price in writingLine-itemed, yours to keep, and nothing starts until you say go.
What Tustin Customers Say
"Fireplace had never drawn properly since we moved in. He found the damper was only opening halfway due to a bent linkage and fixed it in ten minutes."
— Jerome Coleman"Crown was cracked and taking water. Repaired it rather than quoting a rebuild, which the previous company had pushed hard for."
— Rafael Rodriguez"Thorough sweep and a clear report. He was running late from the job before and arrived near the end of the window, though he did call to warn me."
— Kristen Delaney